山東空壓機是如何延長使用年限的？

空壓機在市場上越來越多的被企業所認可，同時也給很多企業帶來了便捷，但是日益上升的成本和整體市場的不景氣，也導致了空壓機改造事業推進變得刻不容緩。那么有哪些方法可以延長空壓機的使用年限，為企業節約成本呢？這里簡單給你講述下平時使用過程中的注意事項：

Air compressor in the market is more and more recognized by enterprises, but also to many enterprises to bring convenience, but the rising cost and the overall market depression, also led to the cause of air compressor energy-saving transformation has become urgent. So what methods can extend the service life of air compressor and save cost for enterprises? Here is a brief introduction to the matters needing attention in the process of normal use:

空壓機主機保養

Maintenance of air compressor

1、空氣壓縮機運轉過程中，隨時注意儀表讀數（特別是氣壓表的讀數），傾聽各部音響，如發現異常情況，應立即停機檢查。貯氣罐內氣壓不許超過銘牌規定的壓力。每工作2~4h,應開啟中間冷卻器和貯氣罐的冷凝油水排放閥門1~2次。搞好機器的清潔工作，空壓機長期運轉后，禁止用冷水沖洗。

1. During the operation of the air compressor, pay attention to the reading of the instrument (especially the reading of the barometer) and listen to the sound of each part. In case of any abnormality, the machine shall be shut down for inspection immediately. The maximum air pressure in the air tank shall not exceed the pressure specified on the name plate. Open the condensate oil-water discharge valve of intercooler and air storage tank for 1-2 times every 2-4h. Do a good job in cleaning the machine, after long-term operation of the air compressor, it is forbidden to wash with cold water.

2、操作人員應穿好工作服，女同志應將發辮塞入工作帽內。嚴禁酒后操作，不得從事與運行無關的事情，不得擅自離開工作崗位，不得擅自決定非本機操作人員代替工作。

2. Operators should wear work clothes, and female comrades should put their braids into their work caps. It is strictly prohibited to operate after drinking, do not engage in matters unrelated to operation, do not leave the post without authorization, and do not decide to replace the work by non operators of the machine.

3、操作人員應經專門培訓，必須了解空氣壓縮機及附屬設備的構造、性能和作用，熟悉運轉操作和維護保養規程。

3. The operators shall be specially trained and must fully understand the structure, performance and function of the air compressor and its auxiliary equipment, and be familiar with the operation and maintenance procedures.

4、定期（每周）對貯氣罐閥進行一次手動排氣試驗，保證閥的有效性。

4. Conduct a manual exhaust test on the safety valve of the air storage tank regularly (weekly) to ensure the safety and effectiveness of the safety valve.

5、搞好機器的清潔工作，空壓機長期運轉后，禁止用冷水沖洗。

5. Do a good job in cleaning the machine, after long-term operation of the air compressor, it is forbidden to wash with cold water.

6、空氣壓縮機起動前，按規定做好檢查和準備工作，注意打開貯氣罐的所有閥門。柴油機啟動后必須施行低速、中速、額定轉速的加熱運轉，注意各儀表讀數是否正常后，方可帶負荷運轉?？諌簷C應逐漸增加負荷啟動，各部分正常后才可全負荷運轉。

6. Before starting the air compressor, check and prepare according to regulations, and pay attention to open all valves of air storage tank. After the diesel engine is started, heating operation at low speed, medium speed and rated speed must be carried out. Pay attention to whether the readings of all instruments are normal before running with load. Air compressor should be gradually increased load start, all parts can be normal before full load operation.

7、定期（每周）對貯氣罐閥進行一次手動排氣試驗，保證閥的有效性。

7. Conduct a manual exhaust test on the safety valve of the air storage tank regularly (weekly) to ensure the safety and effectiveness of the safety valve.

8、在清掃散熱片時，不得用燃燒方法管道油污。清洗、緊固等保養工作必須在停機后進行。用壓縮空氣吹洗零件時，嚴禁將風口對準人體或其他設備，以防傷人毀物。

8. When cleaning the heat sink, it is not allowed to use the combustion method to remove the oil contamination in the pipeline. Cleaning, fastening and other maintenance work must be carried out after shutdown. When cleaning parts with compressed air, it is strictly forbidden to aim the air outlet at the human body or other equipment to prevent injury and damage.

9、經常保持貯存罐外部的清潔。禁止在貯氣罐附近進行焊接或熱加工。貯氣罐每年應作水壓試驗一次，試驗壓力應為工作壓力1.5倍。氣壓表、閥應每年作一次檢驗。

9. Keep the outside of the tank clean at all times. Welding or hot working in the vicinity of air storage tank is prohibited. The air storage tank shall be subjected to hydraulic test once a year, and the test pressure shall be 1.5 times of the working pressure. The barometer and safety valve shall be inspected once a year.

10、空氣壓縮機起動前，按規定做好檢查和準備工作，注意打開貯氣罐的所有閥門。柴油機啟動后必須施行低速、中速、額定轉速的加熱運轉，注意各儀表讀數是否正常后，方可帶負荷運轉?？諌簷C應逐漸增加負荷啟動，各部分正常后才可全負荷運轉。

10. Before starting the air compressor, check and prepare according to regulations, and pay attention to open all valves of air storage tank. After the diesel engine is started, heating operation at low speed, medium speed and rated speed must be carried out. Pay attention to whether the readings of all instruments are normal before running with load. Air compressor should be gradually increased load start, all parts can be normal before full load operation.

11、根據氣溫變化應及時更換相應的壓縮機油，有些地區氣溫特別低，應更換凝點低于當?shù)販囟鹊奶厥庥推贰?/p>

11. According to the change of air temperature, the corresponding compressor oil should be changed in time. In some areas, the temperature is particularly low, so the special oil with condensation point lower than the local temperature should be replaced.

12、機后一定要注意放空所有氣體、排污、放水，放空各種管道及氣包內的水、氣、油，原因是冬季機組工作時，溫度比較高，停機后因外界溫度較低，空氣冷卻會有大量冷凝水產生，存在于各種控制管道、中冷器及氣包內，容易使控制管路、中冷器堵塞，氣包漲裂等隱患。

12. After the unit, it is necessary to pay attention to venting all the gas, blowdown and water, as well as the water, gas and oil in various pipelines and gas bags. The reason is that the temperature is relatively high when the unit is working in winter. After shutdown, due to the low external temperature, a large amount of condensate water will be generated in the air cooling, which exists in various control pipelines, intercoolers and air bags, which is easy to block the control pipeline and intercooler and cause the gas package to expand Cracks and other hidden dangers.